根据国家知识产权局官网20204年4月2日的消息，宜普电源转换公司（Efficient Power Conversion Corporation, EPC，以下简称宜普公司）一件名为“增强型GaN高电子迁移率晶体管器件及其制备方法”的专利(专利号ZL201080015388.2)的核心权利要求6、9、10、13、14、17、18、22-26在无效程序（案件编号：4W116775）中被维持有效。该件专利的无效请求人是英诺赛科（苏州）科技有限公司（以下简称英诺赛科公司）。

According to the information on the official website of the China National Intellectual Property Administration (CNIPA) on April 2, 2024, the key claims 6, 9, 10, 13, 14, 17, 18 and 22-26 of the Chinese patent titled “Enhancement mode GaN HEMT device and method for fabricating the same” (Patent No. ZL201080015388.2) owned by Efficient Power Conversion Corp (“EPC”) have been maintained valid during an invalidation procedure (case number: 4W116775), which was requested by the petitioner Innoscience (Suzhou) Technology Co., Ltd. (“Innoscience”).

Power semiconductors are used across many areas of e-mobility, with different technologies suitable for each part of a vehicle, depending on the voltage and current requirements, while emerging tech is allowing smaller systems to be implemented. With GaN and SiC technologies maturing and coming down in price, adoption is growing, and the technologies are increasingly dominating the design and development of e-mobility powertrain and power systems.

E-Mobility Engineering
March 2024
Read article

The space industry is undergoing a transformative shift to “New Space,” driven by the increasing demand for ubiquitous connectivity and the emergence of innovative business models. One of the key elements of this transformation is the adoption of gallium nitride (GaN) technology in space applications. GaN holds immense potential due to its impressive radiation hardness, high system efficiency and lightweight characteristics.

In a discussion with EE Times Europe, Taha Ayari and Aymen Ghorbel, technology and market analysts at Yole Intelligence, part of Yole Group, explained how New Space—the low Earth orbit (LEO) mission segment, with a typical satellite lifespan of three to five years and lower reliability requirements—has become a focal point for GaN adoption. As a result, power GaN devices are being adopted for various satellite systems, including DC/DC converters, point-of-load systems, motor drives and ion thrusters.

EE Times Europe
October 2023
Read article

Efficient Power Conversion (EPC) is optimistic about GaN despite geopolitical challenges and the changing landscape in the compound semiconductor sector.

DIGITIMES
September, 2023
Read article

Gallium Nitride (GaN) semiconductor company Efficient Power Conversion (EPC) is taking a fresh stab at the power component landscape, challenging the longstanding silicon hegemony.

DIGITIMES
September, 2023
Read article

Transient voltage overshoot is a common phenomenon in GaN high electron mobility transistors (HEMTs) under high slew rate switching conditions. The dynamic parametric instability under such stress is a critical concern for GaN applications. This work, for the first time, accurately characterized the evolution of dynamic on-resistance (R_DS(on)) in GaN HEMTs under repetitive voltage overshoot up to billions of switching cycles. The dynamic R_DS(on) increase was found to be the dominant device degradation under overvoltage switching. Such findings were obtained from a high-frequency, repetitive, unclamped inductive switching (UIS) test with active temperature control and accurate in-situ R_DS(on) monitoring. A physics-based model was proposed to correlate the dynamic R_DS(on) drift with the peak overvoltage, and a good agreement with experimental data was achieved. This model was further used to project the lifetime of GaN HEMTs. For 100 V rated GaN HEMTs switched under 100 kHz and 120 V spikes, the model projects less than 10% dynamic R_DS(on) shift over 25 years of continuous operation. This work addresses the major concerns of overvoltage switching reliability of GaN HEMTs and provides new insights of the electron trapping mechanism.

IEEE Xplore
Ruizhe Zhang, Ricardo Garcia, Robert Strittmatter, Yuhao zhang, Shengke Zhange
Read article (IEEE subscription required)

On July 3^rd, 2023, China’s Ministry of Commerce announced it would put in place certain restrictions on the exporting of gallium and germanium, among other materials, starting in August of this year. EPC’s wafer technology is ‘GaN-on-Si’, although the amount of gallium in each device is miniscule. There are significant sources of gallium available worldwide and EPC’s needs are relatively small, we expect no short or long-term interruption of supply.

In this episode of Spirit: Behind the Screen, Spirit Electronics CEO Marti McCurdy chats with EPC’s CEO Alex Lidow and Marketing Director Renee Yawger about the progress of GaN. They discuss GaN’s performance under high radiation as well as the extensive testing, failure modes and device lifespan detailed in EPC’s Phase 15 reliability report. With the full potential of GaN still to be explored and new EPC products releasing frequently, including new half-bridge drivers, low-side drivers and full power stage, GaN is especially useful in New Space and commercial space applications.

Spirit: Behind the Screen
Listen to podcast

EPC’s GaN Experts will be available during PCIM Europe 2023, showcasing the latest generation of GaN FETs and ICs in a wide variety of real-world applications.

EL SEGUNDO, Calif. — April 2023 — — EPC, the world’s leader in enhancement-mode gallium nitride FETs and ICs,will be delivering multiple technical presentations on GaN technology and showcasing applications at PCIM Europe 2023 in Nuremburg, 09 – 11 May (see detailed schedule below). In addition, the company will demonstrate its latest eGaN^® FETs and ICs in a large variety of customer end products in Hall 9, Stand 318.

In this episode of The EEcosystem Podcast, our guest is Dr. Alex Lidow, CEO and co-founder of Efficient Power Conversion. In this episode, we will find out more about Alex and learn about MOSFETs and the rise of GaN. How did MOSFETs grow so quickly? What technologies are driving GaN adoptions and why. We will also discuss the potential obstacles to GaN adoption. This and many more questions will be answered as we go along! Listen to this episode to learn more!

April, 2023
View video

This article discusses the advantages of GaN-based power stages and introduces a sample device from EPC, implemented in a half-bridge topology. It explains how to use associated development kits to quickly get started on a project. In the process, designers will learn how to measure the parameters of a BLDC motor and operate it in sensorless field orientation control (FOC) with minimal programming effort using Microchip Technology’s motorBench Development Suite.

Digi-Key Electronics
April, 2023
Read article

Efficient Power Conversion (EPC) expands its family of radiation-hardened (rad-hard) gallium nitride (GaN) products for power conversion solutions with two new devices rated at 100 V and 200 V to address a multitude of critical spaceborne and other high-reliability .

EL SEGUNDO, Calif.— April 2023 — EPC announces the introduction of two new radiation-hardened GaN FETs. The EPC7020 is a 200 V, 11 mΩ, 170 A_Pulsed, rad-hard GaN FET in a small 12 mm² footprint. The EPC7003 is a 100 V, 30 mΩ, 42 A_Pulsed, rad-hard GaN FET in a tiny 1.87 mm² footprint.  Both devices have a total dose radiation rating greater than 1,000K Rad(Si) and SEE immunity for LET of 83.7 MeV/mg/cm² with V_DS up to 100% of rated breakdown. These new devices, along with the rest of the Rad Hard family, EPC7019, EPC7014, EPC7004, EPC7018, EPC7007, are offered in a chip-scale package, the same as the commercial eGaN^® FET and IC family.  Packaged versions will be available from EPC Space.

Efficient Power Conversion (EPC) publishes Phase-15 Reliability Report adding to the extensive knowledge base on GaN reliability and mission robustness.

EL SEGUNDO, Calif.— March 2023 — EPC announces the publication of its Phase-15 Reliability Report, documenting continued work using test-to-fail methodology and adding specific reliability metrics and predictions for real world applications including solar optimizers, lidar sensors, and DC-DC converters.

Efficient Power Conversion (EPC) expands its family of footprint compatible ePower™ Stage ICs to boost power density and simplify design for different power requirements in DC-DC applications, motor drives, and class-d audio amplifiers.

EL SEGUNDO, Calif.— March 2023 — EPC announces the introduction of two new 100 V power stage ICs rated at 15 A (EPC23104) and 25 A (EPC23103). The two devices join the 100 V 35 A power stage IC EPC23102 offered by EPC.

With Electronic Power Steering (EPS), the hydraulic system is replaced with an electric motor that aids the driver only when needed. Its digital assistance control can be modified online to adapt to driving conditions. There are, however, several design constraints to consider. One is that the driver does not want to lack the haptic feedback from the tires, especially when a vehicle is large, such as a truck. Other constraints are determined by safety regulations, particularly for automatic guided vehicles. These constraints require adopting an efficient, accurate and redundant system. Gallium nitride technology helps the designers in all these areas.

Power Electronics News
March, 2023
Read article

EL SEGUNDO, Calif.—  March 2023 – Efficient Power Conversion (EPC), the world’s leader in enhancement-mode gallium nitride FETs and ICs, has teamed up with SHARGE Technology (SHARGE) to design a 67 W USB PD charger with a power display screen. The Retro 67 fast charger uses EPC’s 100 V GaN FET, EPC2218, which can deliver 231 A pulsed current in a tiny footprint of 3.5 mm x 1.95 mm offering designers a significantly smaller, more efficient device than silicon MOSFET for USB PD fast chargers.

EPC2218 provides SHARGE’s All-GaN fast charger with higher efficiency, state-of-the-art power density and lower system cost.

Since the launch of GaN-on-Si enhancement mode power transistors in March 2010 there has been a slow but monotonic shift towards adoption and replacement of silicon-based power MOSFETs. Initial adoption came from risk-taker visionaries in applications such as lidar, high-end audio amplifiers, robots, vehicle headlamps, and high-performance DC-DC converters. For the expansion of GaN for power conversion to get beyond the early adopters, a more user-friendly format than the WLCP needed to be developed. This format, however, needed to preserve the key attributes of small size, low RDS(on), high speed, excellent thermal conductivity, and low cost. In other words, the best package would be the least amount of package technically possible. Enter the PQFN…

Bodo’s Power Systems
March, 2023
Read article

With the increase in government mandates to combat climate change, automakers are moving quickly to leverage new technology to respond by switching from the internal combustion engine to electric-drive vehicles. This article presents the design of a 2 kW, two-phase 48 V/12 V bi-directional converter using GaN FETs that achieves 96% efficiency and is targeted for the 48 V mild hybrid system.

PSD North America
March, 2023
Read article Read more

EPC’s GaN Experts will be available during APEC, showcasing the latest generation of GaN FETs and ICs in a wide variety of real-world applications.

EL SEGUNDO, Calif. — March 2023 — EPC, the world’s leader in enhancement-mode gallium nitride FETs and ICs,will be delivering multiple technical presentations at the premier power electronics conference; the IEEE Applied Power Electronics Conference and Exposition (APEC 2023) in Orlando from March 19^th through the 23^rd (see detailed schedule below).  In addition, the company will demonstrate it’s latest generation of eGaN^® FETs and ICs in applications ranging from high-power density computing, eMobility, robotics, solar power, battery charging, and more in booth # 732 in the Orange County Convention Center.  Stop by to see the ‘Wall of GaN’ – the broadest portfolio of GaN power semiconductors in the market available for off-the-shelf delivery.

Five times smaller than an equivalent silicon MOSFET and twice as powerful as the previous generation of eGaN devices is the new sixth generation of devices introduced by Efficient Power Conversion (EPC). We asked CEO Alex Lidow in the video.

Electroniknet.de
November 29, 2022
Watch Video